Australia, New Zealand & the Pacific Airline and RPT Rumours & News in Australia, enZed and the Pacific

Pitot Covers Brisbane Take 2

Old 19th Aug 2022, 01:56
  #1 (permalink)  
Thread Starter
 
Join Date: Feb 2011
Location: Oz
Age: 68
Posts: 1,913
Received 294 Likes on 123 Posts
Pitot Covers Brisbane Take 2

There are no words…

Perhaps we need big fluro flashing signs at the stand or something?

If it was night, they would have departed clearly. Then the fun really starts.

An Australian Transport Safety Bureau investigation preliminary report has detailed that an Airbus A350 passenger aircraft was about to be pushed back for departure from Brisbane Airport before it was observed that covers were still in place on its pitot probes.

https://www.atsb.gov.au/media/news-i...-probe-covers/

Last edited by PoppaJo; 19th Aug 2022 at 02:15.
PoppaJo is offline  
Old 19th Aug 2022, 02:08
  #2 (permalink)  
 
Join Date: Dec 2001
Location: Brisvegas
Posts: 3,860
Likes: 0
Received 233 Likes on 99 Posts
As part of its investigation, to date the ATSB has interviewed the LAME, AME and the refueller, and reviewed airport security video, which did not show that the required final walk-around of the aircraft was conducted by either the LAME or the AME prior to dispatch.
Well done to the observant refueller on an adjacent bay.
Icarus2001 is offline  
Old 19th Aug 2022, 03:37
  #3 (permalink)  
 
Join Date: Jan 2008
Location: Fieldsworthy
Posts: 202
Likes: 0
Received 33 Likes on 17 Posts
Looking at the history, it's obviously a Brisbane thing. They should NOTAM it.
Eclan is offline  
Old 19th Aug 2022, 03:59
  #4 (permalink)  
 
Join Date: Aug 2009
Posts: 509
Likes: 0
Received 0 Likes on 0 Posts
How did the crew pre-flight walk around fail to see this... I assume without any data inputs this would have likely resulted in a rejected take-off due to lack of airspeed data? Or could they have still departed with loss of control risk?
PPRuNeUser0198 is offline  
Old 19th Aug 2022, 04:12
  #5 (permalink)  
 
Join Date: Jun 2006
Location: Perth
Posts: 162
Received 16 Likes on 8 Posts
The External Inspection is basically an excuse to take some selfies for Instagram or TikTok accounts
AviatoR21 is offline  
The following users liked this post:
Old 19th Aug 2022, 04:17
  #6 (permalink)  
 
Join Date: Nov 2014
Location: Timbuktoo
Posts: 259
Received 144 Likes on 43 Posts
How did the crew pre-flight walk around fail to see this
”Between 0852:18 and 0854:03, the first officer conducted a preflight walk-around”.

Because the FO did a walk around of an A350 in less than 2 minutes.

brokenagain is offline  
Old 19th Aug 2022, 04:19
  #7 (permalink)  
 
Join Date: Dec 2014
Location: Australia
Posts: 36
Received 0 Likes on 0 Posts
Have mud wasps ever actually built a nest quickly in any pitot tubes at Brisbane airport? Because if not, I feel this policy about putting on pitot covers during turns is an example of overregulation that actually reduces safety outcomes.
ThunderstormFactory is offline  
Old 19th Aug 2022, 04:25
  #8 (permalink)  
 
Join Date: Apr 2010
Location: Brisbane
Age: 58
Posts: 261
Received 30 Likes on 25 Posts
Originally Posted by ThunderstormFactory
Have mud wasps ever actually built a nest quickly in any pitot tubes at Brisbane airport? Because if not, I feel this policy about putting on pitot covers during turns is an example of overregulation that actually reduces safety outcomes.
Sure have, Etihad was the unlucky airline and they were only on ground for two hours, overall there have been 26 incidents at Brisbane involving wasp activity.
https://www.atsb.gov.au/publications.../final-report/

In 2006 it was only 55 minutes turnaround https://www.atsb.gov.au/publications...601453_001.pdf
markis10 is offline  
Old 19th Aug 2022, 04:44
  #9 (permalink)  
 
Join Date: Mar 2018
Location: Anvya
Posts: 136
Received 42 Likes on 18 Posts
Was suggested on previous post that covers self destruct at a certain speed but idea shot down . Maybe a big orange sign across windshield ? Maybe red streamer across thrust levers that’s kept with covers . Only thing that’s certain it will happen again .
KAPAC is offline  
Old 19th Aug 2022, 04:54
  #10 (permalink)  
 
Join Date: Mar 2002
Location: Seat 1A
Posts: 8,532
Received 72 Likes on 41 Posts
Originally Posted by T Vasis
How did the crew pre-flight walk around fail to see this...
Read the report!

The captain looked up at and likely observed the fitted pitot covers, however they were required to be fitted at that time as per the operator’s policy
At 0904 the LAME re-entered the flight deck, certified for the transit check in the technical log, cleared the technical log entry for the fitment of the pitot covers, and removed the pitot cover warning placard from the flight deck pedestal.
”Between 0852:18 and 0854:03, the first officer conducted a preflight walk-around”.

Because the FO did a walk around of an A350 in less than 2 minutes.
A speedy walkaround indeed but obviously totally irrelevant to the pitot covers issue.
Capn Bloggs is offline  
Old 19th Aug 2022, 05:04
  #11 (permalink)  
Thread Starter
 
Join Date: Feb 2011
Location: Oz
Age: 68
Posts: 1,913
Received 294 Likes on 123 Posts
Originally Posted by T-Vasis
How did the crew pre-flight walk around fail to see this... I assume without any data inputs this would have likely resulted in a rejected take-off due to lack of airspeed data? Or could they have still departed with loss of control risk?
Should result in a RTO but doesn’t always. Both seats chewing up time during the roll second guessing themselves and asking questions. Waiting for V1 which never arrives. Now stuck in the sad and dangerous situation, either High Speed abort (V1 no idea which side) or take it into the air. Many have done this, Malaysian did the same, although even more problematic is they had Captain who had just moved over from a career from the Boeing, who relied on the FO to get it back in.

Airspeed alive goes back the Cessna 172. Airbus no different.
PoppaJo is offline  
Old 19th Aug 2022, 05:53
  #12 (permalink)  
 
Join Date: Aug 2007
Location: All over the Planet
Posts: 867
Received 12 Likes on 5 Posts
Between 0852:18 and 0854:03, the first officer conducted a preflight walk-around. The walk- around was truncated from the nose, to the right engine, across to the left engine and back to the airbridge. The aircraft operator’s procedures also required the extremities of the wings, airframe, and tail section to be inspected, however this was not carried out.
Does this failure amount to negligence? And does the FO still have a job at SQ?
Ken Borough is offline  
Old 19th Aug 2022, 07:22
  #13 (permalink)  
 
Join Date: Dec 2013
Location: Elsewhere
Posts: 608
Received 67 Likes on 27 Posts
Have mud wasps ever actually built a nest quickly in any pitot tubes at Brisbane airport?
How did the crew pre-flight walk around fail to see this..
Mud wasps have caused a number of RTOs at Brisbane. They turn up out of nowhere and work really fast - we’re talking about problems occurring during 30 minute turnarounds. As a result, my outfit leaves the covers fitted until 10-15 minutes before pushback, which isn’t compatible with the timing of our exterior inspection. What happens instead is that there’ll be an open item in the Tech Log which can’t be cleared until the engineer’s removed the covers and physically shown them to the flight crew. Only then will we have a valid Release to Service. If we haven’t seen the removed covers and ensured the Tech Log’s valid, then obviously we shouldn’t be going anywhere.

In a perfect world, we’d be doing the exterior inspection with the jet completely ready to go flying, but that’s rarely how it works, The cargo doors are still open, they’re still refuelling, the NWS lockout pin’s in, the engineer’s headset’s plugged in, etc etc etc. We have to rely on having robust mitigators instead. Having the probe covers still on is much the same. Not ideal, but better than the alternative.
itsnotthatbloodyhard is offline  
Old 19th Aug 2022, 07:34
  #14 (permalink)  
 
Join Date: Jun 2011
Location: The World
Posts: 2,270
Received 322 Likes on 175 Posts
Originally Posted by Ken Borough
Does this failure amount to negligence? And does the FO still have a job at SQ?
Wasn’t the FO or other flight crew’s fault at all.
Pitot covers are meant to stay on until several minutes before pushback, whereas the flight crew walk around usually happens 20-30 minutes before ETD. The SOPs dictated pitot covers would have been on during the flight crew’s walk around.

The mitigation the flight crew had in this case was a warning placard placed on the centre pedestal by the engineer which was only to be removed once they had removed the covers, except in this case they removed the placard without taking the covers off or conducting a final walk around before pushback.

The pilots were following SOP and trusted the engineering to comply with their SOPs.

I know some pilots have a habit of opening the windows, leaning out and physically checking to see the pitot tubes are uncovered in a situation like this, however probably impossible to see from the flight deck of an A350.
dr dre is online now  
Old 19th Aug 2022, 07:35
  #15 (permalink)  
 
Join Date: Dec 2001
Location: Brisvegas
Posts: 3,860
Likes: 0
Received 233 Likes on 99 Posts
Does this failure amount to negligence? And does the FO still have a job at SQ?
It appears that like the last incident, the covers were on during the walk around AS EXPECTED. The crew would wait for the AME to remove them, that is why the engineer signs the ML as such.

Personally I would like to view them before doing any start procedures.
Icarus2001 is offline  
Old 19th Aug 2022, 08:50
  #16 (permalink)  
 
Join Date: Nov 2001
Location: Australia/India
Posts: 5,273
Received 410 Likes on 202 Posts
Ken will hopefully apologise for the inferences which could reasonably be drawn from his questions.

In any event, it’s an odd order of pre-flight inspections (though I understand the justification for it). If there’s stuff left to do which the crew cannot practicably confirm, by first-hand observation before taxiing, it’s little wonder this kind of problem arises.
Lead Balloon is online now  
Old 19th Aug 2022, 09:09
  #17 (permalink)  
 
Join Date: May 2016
Location: Sunshine Coast
Posts: 1,147
Received 181 Likes on 90 Posts
Probably handy to keep Ken's questions in context. He prefaced his questions with a direct quote from the investigation report, specifically,

Between 0852:18 and 0854:03, the first officer conducted a preflight walk-around. The walk-around was truncated from the nose, to the right engine, across to the left engine and back to the airbridge. The aircraft operator’s procedures also required the extremities of the wings, airframe, and tail section to be inspected, however this was not carried out.
Regardless of whether the pitot covers should have still been in place when the FO conducted the preflight walk-around, it is fairly clear that said walk around was manifestly deficient and failed to comply with SQ procedures. Technically it doesn't meet the legal standard for negligence but it was clearly a breach of duty.

I wouldn't expect someone to be sacked for that but neither would I expect there to be no action at all.
MickG0105 is online now  
Old 19th Aug 2022, 10:49
  #18 (permalink)  
 
Join Date: Nov 2001
Location: Australia/India
Posts: 5,273
Received 410 Likes on 202 Posts
As usual (with rare exceptions) a valid point, Mick.

My apologies to Ken if his implied call for the FO’s head was based on the pitot covers remaining on rather than the ‘truncated’ walk-around.
Lead Balloon is online now  
Old 19th Aug 2022, 13:55
  #19 (permalink)  
 
Join Date: Feb 2002
Location: melbourne australia
Posts: 96
Likes: 0
Received 0 Likes on 0 Posts
From personal expereince, the wasps also do their work in fuel drain tubes on aircraft parked at the Brisbane GA area. (Dec 2020)
blackburn is offline  
Old 19th Aug 2022, 14:06
  #20 (permalink)  
 
Join Date: Mar 2002
Location: Seat 1A
Posts: 8,532
Received 72 Likes on 41 Posts
Originally Posted by Cilba
At the airline I worked for it was required that the captain and the first officer viewed the gear pins and covers- three of each- before they were stowed in their dedicated stowage.
That can't be done because of the wasps. Read the report: it describes an alternative procedure (which on this occasion failed).
Capn Bloggs is offline  

Thread Tools
Search this Thread

Contact Us - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service

Copyright © 2024 MH Sub I, LLC dba Internet Brands. All rights reserved. Use of this site indicates your consent to the Terms of Use.